|
11-28-2012, 07:15 PM | #1 |
Jr. Member
Join Date: Jun 2012
Posts: 18
|
My winter storage to do list for my 2001 Nomad
I just wanted to share this with everyone who maybe have a question or two regarding storing the bike for the winter. I have a heated garage to store my bike in which is an advantage. If anyone has some constructive points to add to this list of things to prepare before storing the bike, I will add it to the list. I appreciate all comments.
Storage 2001 Kawasaki Vulcan Nomad Fi Preparation for Storage in a heated garage: -Clean the entire bike thoroughly -Run the engine for about five minutes to warm the oil, shut it off and drain the engine oil. Drain bolt is a 17mm -Remove filter and install new oil filter ( KA16097-0004 ) -Put in fresh engine oil ( KAK61021-093 10w40 synthetic ) or ( SAE 10w40 ) -Remove the spark plugs and spray fogging oil ( Kawasaki K-Kare Fogging Oil #K61030-002 ) directly into each cylinder. Push the starter button for a few seconds to coat the cylinder walls. Stand clear of the the cylinders when doing that. Install the spark plugs NGK DPR6EA-9 -Fill the tank to the top with fuel ( minimum of 90 octane ) ( never fill the tank so the fuel level rises into the filler neck ) that has been treated with Sea Foam which acts as a fuel stabilizer or use a fuel stabilizer -Set the motorcyle on a box or stand -Spray oil on all unpainted metal surfaces to prevent rusting. Avoid getting oil on rubber parts or in the brakes -Remove the battery, and store it where it will not be exposed to direct sunlight, moisture or freezing temperatures, it should be charged from time to time or during storage with the battery in the bike, it should be given a slow charge ( one ampere or less ) about once a month or use a fully automatic, multi-stage charger for 12V batteries 2A trickle charge ( I use the Motomaster Eliminator #011-1506-6 ) This kit includes 3 quick-connect charging leads-standard clamps, ring terminal connectors and 12V accessory plug -Check the coolant ( the factory type of antifreeze is colored green and contains ethylene glycol. It is mixed at 50% and has the freezing point of -35C or -31F. Use a permanent type of antifreeze ( soft water and ethylene glycol plus corrosion and rust inhibitor chemicals for aluminum engines and radiators ) in the cooling system -Put a cover over the motorcyle to keep dust and dirt from collecting on it such as a bed sheet or other fabric that will breath -Cover the exhaust tips so any rodents don’t crawl up them and make a nest. I use hard plastic cups Non heated garage: Everything above except what I read from this contributor zuck vroc #2109 Nomad g/g Ponca City Ok When I lived in Iowa I had a small piece of plywood I would put under the wheels. (pressure left at std). Change the oil is a must because you don't need all that acid in the used oil left to eat on your engine all winter. Also when starting back up in the Spring I would remove the plugs and spray in a little WD 40 to help coat the piston walls, put the plugs back in and start. Also I would change the oil before I started it up in the Spring to avoid getting the condensation that had accumulated over the winter in the works. I would then run about 400 miles and change oil and filter again and was then ready for spring riding. Always used cheap oil for the winter storage and first run in spring. Worked for me for 9 winters. Bike never failed to start and had 160,000 on it when I finally sold it for $300 more than I paid for it 14 yrs earlier.
__________________
2001 Vulcan 1500 Nomad Fi VBA02106 Login or Register to Remove Ads |
|
11-28-2012, 07:19 PM | #2 |
Join Date: Mar 2009
Location: Greeley, Colorado
Posts: 6,772
|
That's a pretty thorough list. You could have just said, clean it, change oil, check coolant.
__________________
Jared
VBA #1051 (Former President) |
|
11-28-2012, 07:48 PM | #3 |
Top Contributor
Join Date: Aug 2008
Location: Everett, Washington
Posts: 5,709
|
In Jared's case....he will do all that....and probably decide to re-custom paint the entire bike, simply because he needs a new shade of color for all those cool pics he takes.... Plus...he just plain needs something to keep him busy over the cold Utah winter...!
__________________
Kris Olsen VBA #0691 2017 HD Ultra Limited Low 2013 Victory Cross Country Tour 2012 1700 Vulcan Voyager 2008 1600 Vulcan Nomad 1997 Vulcan 800 Classic "Growing old is mandatory, but growing up is optional" Custer 2009|Kalispell 2010|Cortez 2010|Crescent City 2011|Kanab 2012|Canmore 2012|Estes Park 2013|Orofino 2014|Lake Tahoe 2015|Red Lodge 2016 |
|
11-28-2012, 07:52 PM | #4 |
Join Date: Jul 2007
Location: Peoples Republic of New York State
Posts: 15,154
|
Wow, can you say OCD boys and girls?
I check the coolant to make sure it is set low enough to not freeze down to -40F, then add Stabil to gas and put them on the smart charger. I don't change the oil till spring. They are stored in an unheated garage. They are dirty from the last ride before they went on life support because it is to freakin cold to wash them.
__________________
Tim "TC" Conley VBA #9 2011 Victory Kingpin mine 2013 Victory Boardwalk -hers [LEFT][COLOR=#000000] [SIZE=4]
Last edited by Top Cat; 11-28-2012 at 07:58 PM.
|
|
11-28-2012, 08:39 PM | #5 |
Join Date: May 2009
Location: Montreal QC
Posts: 12,034
|
I would change the order in which you do a couple of things. When you add stabilizer and top up the tank, you should run the engine for about 5 minutes so the stabilized fuel will be in the whole fuel system not just the tank. You can't do that if you fog first.
__________________
Norm Ward 2008 blue / silver nomad kawanow / VBA #01136 Login or Register to Remove Ads |
|
11-28-2012, 08:51 PM | #6 | |
Join Date: May 2011
Location: Dover, DE
Posts: 1,856
|
Quote:
__________________
Gene Chestnut Dover, DE USAF 1968-1995 VBA#01761 2007 Nomad 1600 Black and Titanium |
|
|
11-28-2012, 10:30 PM | #7 | |
Join Date: Mar 2009
Location: Greeley, Colorado
Posts: 6,772
|
Quote:
__________________
Jared
VBA #1051 (Former President) |
|
|
11-30-2012, 03:54 AM | #8 |
Member
Join Date: Jan 2010
Location: Livingston,La. (Colyell)
Posts: 381
|
If you keep riding year round there is no need to winterize. Throw every thing out of the garage and ride around the garage when time permits. Save money on chemicals, saves time, saves bike from life support, and saves sanity. Win-Win.
Thanks for your time
__________________
'01 carbed Nomad |
|
11-30-2012, 08:58 AM | #9 |
Join Date: May 2009
Location: Montreal QC
Posts: 12,034
|
Carbon monoxide poisoning and vertigo type symptoms, the bike might not need life support, but you will.
__________________
Norm Ward 2008 blue / silver nomad kawanow / VBA #01136 |
|
11-30-2012, 03:00 PM | #10 |
Sr. Contributor
|
I top of with fresh fuel. I then hit the starter and go riding. Been working for me for the last 35 years
__________________
I love my Victory Cross Country Tour 106. Smells like Victory! Ultra's are Limited There are two types of Harley riders. Those that trailer them and those that push them. The most Interesting Man in the World "Find the things in life you don't do well and don't do those things" Member # 0005 |
|