So I need a new stator

[duo1983]

We I just found out that my stators are not working correctly and that an OEM will cost me about $1000. So if any one has replaced there stators before I could use some advice as to what would be a good brand to buy.

[mbarr10]

What Nomad do you have? and year? And Motor? How did you discover it was bad? Could be helpful

[duo1983]

It's an 06 vulcan nomad 1600D I lost all power and had the battery checked out with no issue so the only other thing it could be is the stators

[MrMikey]

.....the only other thing it could be is the stators
Regulator/rectifier? Proper way to tell is to check for AC from the 3 yellow wires from the stator. Common fail place is the plug from the stator................Mike

[recumbentbob]

"I lost all power"

Could be a lot of things. Do your lights work? Main fuse OK?
Your bike has 2 stators kind of unusual for both stators to go bad at same time.

[roadhawg]

I would check main fuse first, may not be bad stators but i have stators from parts bike if you need them?

[duo1983]

Ok will check the wiring. And let ya'll know

[Snake Ranch]

Ok will check the wiring. And let ya'll know


What part of Calif you call home?:???::tup::tup:

[duo1983]

Well I checked the battery its is good after a charge, and I checked the rectifier and stator both check good until I started the bike the voltage was not going up with the throttle applied

[duo1983]

San Diego

[duo1983]

I would check main fuse first, may not be bad stators but i have stators from parts bike if you need them?

that's good to know what are you asking for them?

[MAS Tequila]

What did the meter read out for voltage, both at idle and approximately 2000 rpm?

[duo1983]

What did the meter read out for voltage, both at idle and approximately 2000 rpm?

13.8 at idle and 13.7 with the throttle that was the first time then it dropped to 12.7 the second time around.

[Alcan]

Hi duo, I have a brand new ElectroSport number ESG618 left over when I bought two thinking I have two bad rotors but found out only the outside unit was shorted. I replaced the out side stator now the voltage out put is good. It's stated that this will fit up to 2008 1600 Vulcan. I will sell it to you for $92.00 shipped Priority Mail.

[duo1983]

Hi duo, I have a brand new ElectroSport number ESG618 left over when I bought two thinking I have two bad rotors but found out only the outside unit was shorted. I replaced the out side stator now the voltage out put is good. It's stated that this will fit up to 2008 1600 Vulcan. I will sell it to you for $92.00 shipped Priority Mail.

thanks, but I just had a second look at my bike and found out that it was the rectifiers that are bad.